1991-Montero-Service-Manual · trouble shooting · страница 6 из 63 · Открыть оригинал PDF ↗
| Open solenoid pull-in wire | See Testing in STARTER article | |
|---|---|---|
| Starter Does Not Operate and Headlights Dim | Weak battery or dead cell Loose or corroded battery connections | Charge or replace battery as necessary Check that battery connections are clean and tight |
| Internal ground in starter windings | See Testing in STARTER article | |
| Grounded starter fields | See Testing in STARTERS | |
| Armature rubbing on pole shoes | See STARTER article | |
| Starter Turns but Engine | Starter clutch slipping | See STARTER article |
| Does Not Rotate | Broken clutch housing | See STARTER article |
| Pinion shaft rusted or dry | See STARTER article | |
| Engine basic timing incorrect | See Ignition Timing in TUNE-UP article | |
| Broken teeth on engine flywheel | Replace flywheel and check for starter pinion gear damage | |
| Starter Will Not Crank Engine | Faulty overrunning clutch | See STARTER article |
| Broken clutch housing | See STARTER article | |
| Broken flywheel teeth | Replace flywheel and check for starter pinion gear damage | |
| Armature shaft sheared or reduction gear teeth stripped | See STARTER article | |
| Weak battery | Charge or replace battery as necessary | |
| Faulty solenoid | See On-Vehicle Tests in STARTER article | |
| Poor grounds | Check all ground connections for tight and clean connections | |
| Ignition switch faulty or misadjusted | Adjust or replace ignition switch as necessary | |
| Starter Cranks Engine Slowly | Battery weak or defective | Charge or replace battery as necessary |
Таблица в оригинале
Оригинальная страница руководства
